Investigation of Performance and Emission Characteristics on VCR Engine Utilizing Varied Injection Timing and Compression Ratio of Microalgae Biodiesel Blend

Jump To References Section

Authors

  • Swapnil Galande
     Department of Mechanical Engineering, Amrutvahini College of Engineering, Sangamner, SPPU Pune, Sangamner - 422608, Maharashtra ,IN
  • D. R. Pangavhane
     Government College of Engineering, Avasari Khurd, Pune - 412405, Maharashtra ,IN
  • Shubham R. Suryawanshi
     Department of Mechanical Engineering, MET's Institute of Engineering, Nashik, SPPU, Pune - 422207, Maharashtra ,IN

DOI:

https://doi.org/10.18311/jmmf/2023/41770

Keywords:

Diesel Engine, GRA, L27 Array, Microalgae Biodiesel, Taguchi Method

Abstract

An analysis of the performance and emission parameters using varying injection timing and compression ratio with a Microalgae Biodiesel blend was done to optimize the input parameter using grey relational analysis and Taguchi analysis. For this the microalgae biodiesel blends were used as B10 (MB10+PD90), B20 (MB20+PD80) and B30 (MB30+PD70) and the compression ratios were used as 17:1, 19:1 and 21:1. Injection timing where used as 21̊ bTDC, 23̊ bTDC, 25̊ bTDC and load was varied as 3, 6 and 12 to optimize the blend. The purpose was to address numerous response optimization problems with a limited number of experimental runs using the Taguchi approach and L27 orthogonal analysis. To determine the best combination of four input parameters, the data from this experiment was further examined using the signal-to-noise ratio and grey relational analysis. The aim was to reduce emission parameters such as NOx, CO, HC and Smoke, as well as the Brake-Specific Fuel Consumption (BSFC) and Exhaust Gas Temperature (EGT) and to increase performance parameters, i.e. Brake Thermal Efficiency (BTE). From the above study, it was observed that B20 (MB20+PD80) has shown optimum results for performance and emission parameters at 21:1 compression ratio, 23̊ bTDC injection timing and 12kg load.

Downloads

Download data is not yet available.

Metrics

Metrics Loading ...

Downloads

Published

2023-12-01

How to Cite

Galande, S., Pangavhane, D. R., & Suryawanshi, S. R. (2023). Investigation of Performance and Emission Characteristics on VCR Engine Utilizing Varied Injection Timing and Compression Ratio of Microalgae Biodiesel Blend. Journal of Mines, Metals and Fuels, 71(12), 2757–2772. https://doi.org/10.18311/jmmf/2023/41770

Issue

Volume 71, Issue 12, December 2023

Section

Articles

License

Creative Commons License

This work is licensed under a Creative Commons Attribution-NonCommercial 4.0 International License.

Crossref
Scopus
Google Scholar
Europe PMC

 

References

Marafi A, Albazzaz H, Rana MS. Hydroprocessing of heavy residual oil: Opportunities and challenges. Catal Today. 2019; 329:125-34. https://doi.org/10.1016/j.cattod.2018.10.067

Chia SR, Nomanbhay S, Ong MY, Bin Shamsuddin AH, Chew KW, Show PL. Renewable diesel as fossil fuel substitution in Malaysia: A review. Fuel. 2022; 314:123-37. https://doi.org/10.1016/j.fuel.2022.123137

Agency IE. International Energy Agency (IEA) World Energy Outlook [Internet]. 2022. Available from: https://www.Iea.Org/Reports/World-Energy-Outlook-2022/Executive-Summary

Bridge G, Le Billon, Oil P. John Wiley & Sons; 2017.

Dey S, Reang NM, Das PK, Deb M. A comprehensive study on prospects of economy, environment, and efficiency of palm oil biodiesel as a renewable fuel. J Clean Prod. 2021; 286. https://doi.org/10.1016/j.jclepro.2020.124981

Cherwoo L, Gupta I, Flora G, Verma R, Kapil M, Arya SK, et al. Biofuels an alternative to traditional fossil fuels: A comprehensive review. Sustain Energy Technol Assessments. 2023; 60. https://doi.org/10.1016/j.seta.2023.103503

Ershov MA, Savelendo VD, Makhova UA, Makhmudova AE, Zuikov AV, Kupustin VM, et al. Current challenge and innovative progress for producing HVO and FAME biodiesel fuels and their applications. Waste Biomass Valori. 2023; 14:505-21. https://doi.org/10.1007/s12649-022-01880-0

Neupane D. Biofuels from renewable sources, a potential option for biodiesel production. Bioengineering. 2022; 10. https://doi.org/10.3390/bioengineering10010029 PMid:36671601 PMCid:PMC9855116

Khalid Z, Alam SN, Guldhe A, Singh B. Novel feedstocks for biofuels: Current scenario and recent advancements. 2022; 17-37. https://doi.org/10.1007/978-981-19-3582-4_2

Mishra RK, Chistie SM, Naik SU, Mohanty K. Feedstock for biofuel production. Bioenergy Engineering. 2023; 17-50. https://doi.org/10.1016/B978-0-323-98363-1.00008-9

Sambasivam KM, Kuppan P, Laila LS, Shashirekha V, Tamilarasan K, Abinandan S. Kernel-based biodiesel production from non-edible oil seeds: Techniques, optimization, and environmental implications. Energies. 2023; 16. https://doi.org/10.3390/en16227589

Nagaraja S, Prakash KS, Sudhakaran R, Kumar MS. Investigation on the emission quality, performance and combustion characteristics of the compression ignition engine fueled with environmental friendly corn oil methyl ester - Diesel blends. Ecotoxicol Environ Saf. 2016; 134:455-61. https://doi.org/10.1016/j.ecoenv.2016.01.023 PMid:26849952

Ozsezen AN, Canakci M. Determination of performance and combustion characteristics of a diesel engine fueled with canola and waste palm oil methyl esters. Energy Convers Manag. 2011; 52:108-16. https://doi.org/10.1016/j.enconman.2010.06.049

Nandi S, Gonela V, Awudu I. A resource-based and institutional theory-driven model of large-scale biomass-based bioethanol supply chains: An emerging economy policy perspective. Biomass Bioenergy. 2023; 174. https://doi.org/10.1016/j.biombioe.2023.106813

Li Y, Wen Y, Chen B, Fu X, Wu Y. The dilemma and potential development of biodiesel in China - In view of production capacity and policy. Energy Sustain Dev. 2023; 75:60-71. https://doi.org/10.1016/j.esd.2023.05.005

Mahapatra S, Kumar D, Singh B, Sachan P. K. Biofuels and their sources of production: A review on cleaner sustainable alternative against conventional fuel, in the framework of the food and energy nexus. Energy Nexus. 2021; 4. https://doi.org/10.1016/j.nexus.2021.100036

Almomani F, Hosseinzadeh-Bandbafha H, Aghbashlo M, Omar A, Joo S-W, Vasseghian Y, et al. Comprehensive insights into conversion of microalgae to feed, food, and biofuels: Current status and key challenges towards implementation of sustainable biorefineries. Chem Eng J. 2023; 455. https://doi.org/10.1016/j.cej.2022.140588

Alazaiza YDM, Albahnasawi A, Al Maskari T, Abujazar MSS, Bashir MJK, Nassani DE, et al. Biofuel production using cultivated algae: Technologies, economics, and its environmental impacts. Energies. 2023; 16:13-16. https://doi.org/10.3390/en16031316

Rajak U, Nashine P, Dasore A, Verma TN. Utilization of renewable and sustainable microalgae biodiesel for reducing the engine emissions in a diesel engine. Fuel. 2022; 311. https://doi.org/10.1016/j.fuel.2021.122498

Tüccar G, Aydın K. Evaluation of methyl ester of microalgae oil as fuel in a diesel engine. Fuel. 2013; 112:203-7. https://doi.org/10.1016/j.fuel.2013.05.016

Rahman MA, Aziz MA, Ruhul AM, Rashid MM. Biodiesel production process optimization from Spirulina maxima microalgae and performance investigation in a diesel engine. J Mech Sci Technol. 2017; 31:3025-33. https://doi.org/10.1007/s12206-017-0546-x

Karmakar R, Kundu K, Rajor A. Fuel properties and emission characteristics of biodiesel produced from unused algae grown in India. Pet Sci. 2018; 15:385-95. https://doi.org/10.1007/s12182-017-0209-7

Dash SK, Lingfa P, Barik D. Combined adjustment of injection timing and compression ratio for an agricultural diesel engine fuelled with Nahar methyl ester. Int J Ambient Energy. 2022; 43:1482-94. https://doi.org/10.1080/01430750.2020.1712250

Pohit G, Misra D. Optimization of performance and emission characteristics of diesel engine with biodiesel using Grey-Taguchi Method. J Eng. 2013; 2013:1-8. https://doi.org/10.1155/2013/915357

Jadhav SD, Tandale MS. Multi-objective performance optimization of compression ignition engine operated on mangifera indica biodiesel by applying Taguchi grey relational analysis. Waste Biomass Valori. 2016; 7:1309-25. https://doi.org/10.1007/s12649-016-9504-6

Chen L, Liu T, Zhang W, Chen X, Wang J. Biodiesel production from algae oil high in free fatty acids by two-step catalytic conversion. Bioresour Technol. 2012; 111:208-14. https://doi.org/10.1016/j.biortech.2012.02.033 PMid:22401712

Galande S, Pangavhane DR, Campli S. Effect of compression ratio and injection timing on the performance of microalgae‐based biodiesel blend. Heat Transf. 2023. https://doi.org/10.1002/htj.22983

Karmakar R, Rajor A, Kundu K, Kumar N. Production of biodiesel from unused algal biomass in Punjab, India. Pet Sci. 2018; 15:164-75. https://doi.org/10.1007/s12182-017-0203-0

Ross PJ. Taguchi techniques for quality engineering: Loss function, orthogonal experiments, parameter and tolerance design, McGraw Hill; 1988.

Ayhan V, Çangal C, Cesur I, Çoban A, Ergen G, Çay Y, et al. Optimization of the factors affecting performance and emissions in a diesel engine using biodiesel and EGR with Taguchi method. Fuel. 2020; 261. https://doi.org/10.1016/j.fuel.2019.116371

Mahla SK, Goyal T, Goyal D, Sharma H, Dhir A, Goga G. Optimization of engine operating variables on performance and emissions characteristics of biogas fuelled CI engine by the design of experiments: Taguchi approach. Environ Prog Sustain Energy. 2022; 41. https://doi.org/10.1002/ep.13736

Sharma A, Maurya NK, Singh Y, Singh NK, Gupta SK. Effect of design parameters on performance and emissions of DI diesel engine running on biodiesel-diesel blends: Taguchi and utility theory. Fuel. 2020; 281. https://doi.org/10.1016/j.fuel.2020.118765

Moran J, Granada E, Míguez JL, Porteiro J. Use of grey relational analysis to assess and optimize small biomass boilers. Fuel Process Technol. 2006; 87:123-27. https://doi.org/10.1016/j.fuproc.2005.08.008

Parida MK, Joardar H, Rout AK, Routaray I, Mishra BP. Multiple response optimizations to improve performance and reduce emissions of Argemone Mexicana biodiesel-diesel blends in a VCR engine. Appl Therm Eng. 2019; 148:1454-66. https://doi.org/10.1016/j.applthermaleng.2018.11.061.

Soni AK, Kumar S, Pandey M. Performance comparison of microalgae biodiesel blends with petro-diesel on variable compression ratio engine. J Inst Eng Ser E. 2022; 103:53-63. https://doi.org/10.1007/s40034-020-00183-0

Sharif SK, Rao BN, Jagadish D. Comparative performance and emission studies of the CI engine with Nodularia Spumigena microalgae biodiesel versus different vegetable oil derived biodiesel. SN Appl Sci. 2020; 2:858. https://doi.org/10.1007/s42452-020-2697-0.

Kale B, Das PS, Khawale V, Lutade S. Performance and exhaust emission characteristics investigation of compression ignition engine fuelled with microalgae biodiesel and its diesel blends. Environ Sci Pollut Res. 2021; 30:25417-26. https://doi.org/10.1007/s11356-021-17587-z PMid:34845638.

Tan P, Hu Z, Lou D, Li Z. Exhaust emissions from a light-duty diesel engine with Jatropha biodiesel fuel. Energy. 2012; 39:356-62. https://doi.org/10.1016/j.energy.2012.01.002.

Venkatesan EP, Murugesan P, Pichika SVVSN, Janaki DV, Javed Y, Mahmoud Z, et al. Effects of injection timing and antioxidant on NOx reduction of CI engine fueled with algae biodiesel Blend using machine learning techniques. Sustainability. 2022; 15:603. https://doi.org/10.3390/su15010603.

Mohankumar S, Senthilkumar P. Particulate matter formation and its control methodologies for diesel engine: A comprehensive review. Renew Sustain Energy Rev. 2017; 80:1227-38. https://doi.org/10.1016/j.rser.2017.05.133

Pal A, Verma A, Kachhwaha SS, Maji S. Biodiesel production through hydrodynamic cavitation and performance testing. Renew Energy. 2010; 35:619-24. https://doi.org/10.1016/j.renene.2009.08.027.