Influence of Processing Techniques on the Saponin Content and Nutritional Quality of Quinoa (Chenopodium quinoa)

Jump To References Section

Authors

  • Priyanka R. Kale
     Department of Food Business Management, College of Food Technology, Vasantrao Naik Marathwada Krishi Vidyapeeth, Parbhani – 431401, Maharashtra ,IN
  • D. R. More
     Department of Food Business Management, College of Food Technology, Vasantrao Naik Marathwada Krishi Vidyapeeth, Parbhani – 431401, Maharashtra ,IN
  • Ganesh P. Gaikwad
     Department of Food Business Management, College of Food Technology, Vasantrao Naik Marathwada Krishi Vidyapeeth, Parbhani – 431401, Maharashtra ,IN
  • V. D. Surve
     Department of Food Business Management, College of Food Technology, Vasantrao Naik Marathwada Krishi Vidyapeeth, Parbhani – 431401, Maharashtra ,IN
  • Aditi H. Bachate
     Department of Food Business Management, College of Food Technology, Vasantrao Naik Marathwada Krishi Vidyapeeth, Parbhani – 431401, Maharashtra ,IN

Keywords:

Antinutritional, Bitterness, Nutrient, Pretreatment, Quinoa

Abstract

Quinoa cultivated primarily for its edible seeds is renowned for its nutritional richness. The study highlights how each method affects quinoa’s nutritional composition and saponin content by comparing different processing techniques. This information is valuable for food processors and manufacturers seeking to optimise their production processes to enhance their nutritional value. The soaking process involved immersing the seeds in sodium bicarbonate and citric acid solution (1% and 2%, respectively) for 6 hours at room temperature then roasting at 800C for 10 min. These pretreated quinoa grains were analyzed for their saponin content and nutritional composition. In raw quinoa grains, the saponin content was measured at 0.64%. After soaking the grains in a 2% citric acid solution, a significant reduction in saponin content to 0.09%. However, roasting the quinoa grains results in a decreased saponin content slightly to 0.62%. The results indicate that soaking in a 2% citric acid solution was particularly effective in reducing the saponin content of quinoa seeds to a desirable level while also eliminating bitterness. Consequently, quinoa seeds treated with a 2% citric acid solution were selected for further nutritional analysis. Significant alterations in the nutritional composition of quinoa were observed as a result of processing. In terms of proximate composition, soaking increased moisture, protein, and ash while decreasing other parameters. Soaking causes an increase in protein content from 15.6% to 16.2%. Conversely, roasting decreased moisture and protein levels while increasing other parameters. The moisture and protein content of roasted quinoa grains were reduced to 6.8% and 14.8%, respectively. Both soaking and roasting processes resulted in elevated mineral content in quinoa seeds. Consequently, soaked and roasted quinoa grains were found to be rich in nutrients, positioning them as valuable sources for enhancing food commercialization.

Downloads

Download data is not yet available.

Downloads

Published

2024-06-10

How to Cite

Kale, P. R., More, D. R., Gaikwad, G. P., Surve, V. D., & Bachate, A. H. (2024). Influence of Processing Techniques on the Saponin Content and Nutritional Quality of Quinoa (<i>Chenopodium quinoa</i>). Toxicology International. Retrieved from https://informaticsjournals.com/index.php/toxi/article/view/43419

Issue

Online First

Section

Articles

License

Copyright (c) 2024 Priyanka R. Kale, D. R. More, Ganesh P. Gaikwad, V. D. Surve, Aditi H. Bachate

Creative Commons License

This work is licensed under a Creative Commons Attribution 4.0 International License.

Received 2024-03-30
Accepted 2024-05-20
Published 2024-06-10

 

References

Sharma V, Chandra S, Dwivedi P, Parturkar M. Quinoa: A nutritional health grain. Ind J Pure App Biosci. 2015; 3(9):725-36.

Arneja I, Tanwar B, Chauhan, A. Nutritional composition and health benefits of golden grain of 21st century, quinoa (Chenopodium quinoa willd.). Pak J Nutr. 2015; 14(12):1034- 40. https://doi.org/10.3923/pjn.2015.1034.1040

Saeed MS, Saeed A, Iqbal M, Adnan M. Nutritional benefits of quinoa review. Ind J Pure App Biosci. 2020; 8(6):624-27. https://doi.org/10.18782/2582-2845.8493

Maradini-Filho AM, Pirozi MR, Borges JT, Santana HM, Chaves JB. Quinoa: Nutritional, functional and anti-nutritional aspects. Food Sci Nutr. 2017; 57(8):1618-30. https://doi.org/10 .1080/10408398.2014.1001811 PMid:26114306

United Nations. Press Release. Secretary-general statements and messages. Launching international year of quinoa. New York; 2013 February 20. Secretary General SG/SM/14825 GA/11340 OBV/1184.

Valencia-Chamorro S. Quinoa: Encyclopedia of food sciences and nutrition. 2nd edn. Amsterdam: Academic Press; 2003. https://doi.org/10.1016/B0-12-227055-X/00995-0

Vilche C, Gely M, Santalla E. Physical properties of quinoa seeds. Biosyst Eng. 2003; 86(1):59-65. https://doi. org/10.1016/S1537-5110(03)00114-4

Valentina M, Francesca M. Functional components and antinutritional factors in gluten-free grains: A focus on quinoa seeds. Foods. 2021; 10(2):351. https://doi.org/10.3390/ foods10020351 PMid:33562277 PMCid:PMC7915320

Miranda M, Vega-Galvez A, Quispe-Fuentes I, Rodríguez MJ, Maureira H, Martínez EA. Nutritional aspects of six quinoa (Chenopodium quinoa willd.) ecotypes from three geographical areas of Chile. Chil J Agric Res. 2012; 72(2):175- 81. https://doi.org/10.4067/S0718-58392012000200002

Zhu N, Sheng S, Li D, Lavoie EJ, Karwe MV, Rosen RT, et al. Antioxidative flavonoid glycosides from quinoa seeds (Chenopodium quinoa). J Food Lipids. 2002; 8(1):37-44. https://doi.org/10.1111/j.1745-4522.2001.tb00182.x

Kuljanabhagavad T, Wink M. Biological activities and chemistry of saponins from Chenopodium quinoa willd. Phytochem Rev. 2009; 8(2):473-90. https://doi.org/10.1007/ s11101-009-9121-0

Gomez-Caravaca AM, Iafelice G, Verardo V, Marconi E, Caboni, MF. Influence of pearling process on phenolic and saponin content in quinoa (Chenopodium quinoa willd.). Food Chem. 2014; 157:174-8. https://doi.org/10.1016/j. foodchem.2014.02.023 PMid:24679767

Araujo-Farro PC, Podadera G, Sobral PJ, Menegalli FC. Development of films based on quinoa (Chenopodium quinoa willd.) starch. Carbohydr Polym. 2010; 81(4):839- 48. https://doi.org/10.1016/j.carbpol.2010.03.051

Afrose S, Tsujii H, Hossain MS, Salma U, Miah AG. Dietary karaya saponin and Rhodobacter capsulatus exert hypocholesterolemic effects by suppression of hepatic cholesterol synthesis and promotion of bile acid synthesis in laying hens. Cholesterol. 2010:1-7. https://doi.org/10.1155/2010/272731 PMid:21490913 PMCid:PMC3065839

Vega-Gálvez A, Miranda M, Vergara J, Uribe E, Puente L, Martínez E. Nutrition facts and functional potential of quinoa (Chenopodium quinoa willd.), an ancient Andean grain: A review. J Sci Food Agric. 2010; 90(15):2541-7. https://doi.org/10.1002/jsfa.4158 PMid:20814881

Irigoyen RM, Giner SA. Extraction kinetics of saponins from quinoa seed (Chenopodium quinoa willd). Int J Food Stud. 2018; 7(2):76-88. https://doi.org/10.7455/ ijfs/7.2.2018.a7

Sandhya PS, Haripriya A. Effect of pre-treatment on selected nutrient profile and functional properties of quinoa (Chenopodium quinoa) flour and development of gluten free quinoa cookies. Indian J Nutr Diet. 2018; 55(2):197-208. https://doi.org/10.21048/ ijnd.2018.55.2.18156

AOAC. Official methods of analysis. 16th ed. Association of Official Analytical Chemists, Washington, DC; 2005.

Obdoni BO, Ochuko PO. Phytochemical studies and comparative efficacy of the crude extracts of some Homostatic plants in Edo and Delta States of Nigeria. Global J Pure Appl Sci. 2001; 8(2):203-208. https://doi. org/10.4314/gjpas.v8i2.16033

Jan KN, Panesar PS, Singh S. Effect of moisture content on the physical and mechanical properties of quinoa seeds. Int Agrophys. 2019; 33:41-8. https://doi.org/10.31545/ intagr/104374

Gemede HF, Ratta N. Antinutritional factors in plant foods: Potential health benefits and adverse effects. Int J Nutr Food Sci. 2014; 3:284-9. https://doi.org/10.11648/j. ijnfs.20140304.18

Chauhan GS, Eskin NA, Tkachuk R. Nutrients and antinutrients in quinoa seed. Cereal Chem. 1992; 69(1):85-8.

Mohammad NA. Studies on physico-chemical and nutritional properties of quinoa seed (chenopodium quinoa willd.) and its exploration in cookies. Vasantrao Naik Marathwada Krishi Vidyapeeth, Parbhani; 2019

Ruales J, Nair BM. Effect of processing on the digestibility of protein and availability of starch in quinoa (Chenopodium quinoa willd.) seeds. Department of applied nutrition, university of Lund, Sweeden. Escuala Politecnica Nacional. Quito, Ecuador; 1993.

Nonogaki H, Bassel GW, Bewley JW. Germinationstill a mystery. Plant Sci. 2010; 179:574- 81. https://doi. org/10.1016/j.plantsci.2010.02.010

Jemima B, Kumar M, Indu V.R. Nutrient and antioxidant analysis of raw and processed minor millets. Elixir Food Sci. 2012; 52A:1279-82.

Rumiyati A, James P, Jayasena V. Effect of germination on the nutritional and protein profile of Australian Sweet Lupin (Lupinus angustifolius L.). Food Nutr Sci. 2012; 3(5):621-6. https://doi.org/10.4236/fns.2012.35085

Adegunwa MO, Adebowale AA, Solano EO. Effect of thermal processing on the biochemical composition, anti-nutritional factors and functional properties of Beniseed (Sesamum indicum) flour. Am J Bio Mol Biol. 2012; 2(3):175-82. https://doi.org/10.3923/ ajbmb.2012.175.182

Marmouzi I, El Madani N, Charrouf Z, Cherrah Y, Faouzi MYE. Proximate analysis, fatty acids and mineral composition of processed Moroccan Chenopodium quinoa willd. and antioxidant properties according to the polarity. Phytotherapie. 2015; 13(2):110-17. https://doi.org/10.1007/ s10298-015-0931-5

Sahni CK, Khurdiya DS, Dalal MA, Maini SB. Microwave processing of foods-potential and prospects. Ind Food Pack. 1997; 5:32-41.

Beltagi HS. Effect of roasting on protein fraction profiles and enzyme activities of Egyptian peanut. Int J Food Sci Nutr. 2011; 62(5):453-6. https://doi.org/10.3109/09637486 .2010.544642 PMid:21338250

Adeyeye EI. Effect of cooking and roasting on the amino acid composition of raw groundnut (Arachis hypogaea) seeds. Acta Sci Pol Technol. 2010; 9(2):201-16.

Rajni M, Nagi HP, Sharma P, Sharma S. Effect of processing on chemical composition and antinutritional factors in chickpea flour. J Food Sci Eng. 2012; 2:180-6. https://doi. org/10.17265/2159-5828/2012.03.008

Chaudhary N, Vyas S. Effect of germination on proximate composition and anti-nutritional factor of millet (ragi) based premixes. Int J Food Nutr Sci. 2014; 3(4):72-9.

Ezeokonkwo CA. Effect of roasting on the nutrient composition of Terminallia catappal seed. New Jersey Nurs Stud, Inc. 2005; 26(1):19-24.

Inyang UE, Akpan EO, Bello FA. Effect of boiling and roasting on the nutrient and anti-nutrient contents in conophor nut flour. Int J Inf Res Rev. 2015; 2(6):769-72.

Rosa M, Hilal M, Gonzalez JA, Prado FE. Low-temperature effect on enzyme activities involved in sucrose–starch partitioning in salt-stressed and saltacclimated cotyledons of quinoa (Chenopodium quinoa willd.) seedlings. Plant Physiol Biochem. 2009; 47:300-7. https://doi.org/10.1016/j. plaphy.2008.12.001 PMid:19124255

Coulibaly A, Kouakou B, Chen J. Extruded adult breakfast based on millet and soybean: Nutritional and functional qualities, source of low glycemic food. J Nutr Food Sci. 2012; 2:151-60. https://doi.org/10.4172/2155-9600.1000151

Gunashree BS, Selva KR, Roobini R, Venkateswaran G. Nutrients and antinutrients of ragi and wheat as influenced by traditional processes. Int J Curr Microbiol Appl Sci. 2014; 3(7):720-36.